All Issue

2018 Vol.34, Issue 11 Preview Page

Research Article

Laboratory Experiments for Evaluating Dynamic Response of Small-scaled Circular Steel Pipe

실내 실험을 통한 소형 모형 원형 강관의 동적 반응 평가

Jung Uk Song1
,
Jong-Sub Lee2
,
Min-Chul Park3
,
Yong-Hoon Byun4
,
Jung-Doung Yu5*
송 정욱1
,
이 종섭2
,
박 민철3
,
변 용훈4
,
유 정동5*
1Ph.D. Student, School of Architecture and Civil Engrg., Korea Univ.
2Prof., School of Architecture and Civil Engrg., Korea University
3Ph.D. Candidate, School of Architecture and Civil Engrg., Korea Univ.
4Assistant Prof., School of Agricultural Civil & Bio-Industrial Engrg., Kyungpook National Univ.
4Reserch Prof., School of Architecture and Civil Engrg., Korea Univ.
1고려대학교 건축사회환경공학부 박사과정
2고려대학교 건축사회환경공학부 교수
3고려대학교 건축사회환경공학부 박사수료
4경북대학교 농업토목･생물산업공학부 조교수
4고려대학교 건축사회환경공학과 연구교수
*Corresponding Author
30 November 2018. pp. 81-92
PDF XML Citation
Abstract

For a marine bridge foundation construction, a large-circular-steel-pipe has been proposed for supporting vertical load and preventing water infiltration. However, a ship collision can adversely affect the structural stability. This paper presents a fundamental study on dynamic responses of the large-circular-steel-pipe by an impact load. In laboratory experiments, small-scaled steel pipe is installed in a soil tank. The soil height and water level are set to 23 cm and 25~70 cm, respectively. The upper part of the steel pipe is impacted using a hammer to simulate the ship collision. The dynamic responses are measured using accelerometers and strain gauges. Experimental results show that the strain decreases as the measured location is lowered. The higher frequency components appear in the impact load condition compared to the microtremor condition. However, the higher frequency components measured at the strain gauge located below the water level do not appear. For the accelerometer signal, the maximum frequency under the impact load is higher than that of the microtremor. The maximum frequency decreases as water level increases but it is larger than the maximum frequency of the microtremor. This study shows that strain gauge and accelerometer can be useful for evaluating the dynamic responses of large-circular-steel-pipes.

Keywords
Accelerometer
Large Circular Steel Pipe
Dynamic Response
Ship Collision
Strain gauge

최근 해상 교량 기초 시공 중 차수 및 연직 하중을 지지하는 역할을 수행하는 대형 원형 강관 가설 공법이 제안되었다. 하지만, 대형 원형 강관의 시공 및 운용 중에 발생할 수 있는 선박 충돌과 같은 위부 요인은 구조물의 안정성에 악영향을 줄 수 있다. 따라서, 본 연구에서는 외부 충격에 의한 대형 원형 강관의 동적 반응을 평가할 수 있는 기법을 개발하기 위해 실내 실험을 통한 기초 연구를 수행하였다. 실내 실험에서는 해상에 설치된 대형 원형 강관을 모사하기 위하여 소형 모형 강관을 토조에 설치하였고, 토조 속 흙의 높이와 수위는 각각 23cm와 25cm로 설정하였다. 수위는 40cm, 55cm, 70cm로 변화시켜가며 실험을 수행하였다. 선박 충돌을 모사하기 위하여 모형 강관의 상부를 해머로 타격하였으며, 모형 강관의 길이 방향으로 설치된 변형률계와 상부에 설치된 가속도계로 신호를 측정하였다. 실험 결과, 변형률계로 측정된 변형률이 모형 강관의 상부에서 하부로 내려갈수록 감소하였다. 변형률계로 측정된 신호의 주파수는 충격이 가해지면 상시미진동 주파수보다 크게 증가하였지만, 수위 아래에 위치한 변형률계에서 측정된 주파수는 큰 증가를 나타내지 않았다. 가속도계로 측정된 신호의 최대 주파수는 충격이 가해지면 상시미진동 주파수보다 크게 증가하였다. 수위가 증가하면 최대 주파수는 감소하지만, 상시미진동 주파수보다는 크게 나타났다. 본 연구의 결과는 변형률계와 가속도계가 대형 원형 강관의 동적 반응 특성을 평가하는데 유용한 지표가 될 수 있음을 보여준다.

References
1
Bae, Y.G. and Lee, S.L. (2008), "Analysis of Ship Collision behavior of Pile Supported Structure", Journal of Korean Society of Civil Engineers, Vol.28, No.3A, pp.323-330 (in Korean).
2
Bae, Y.G. and Lee, S.L. (2013), "Ship Collision Risk Assessment and Sensitivity Analysis for Sea-crossing Bridges", Journal of the Korean Society of Civil Engineers, Vol.33, No.5, pp.1753-1763 (in Korean).
10.12652/Ksce.2013.33.5.1753
3
Cho, H.H. (2009), Probability analysis of ship-bridge collision using ship maneuvering simulation, Ph.D. Dissertation, Seoul National University, Korea (in Korean).
4
KICT, Korea Institute of Civil Engineering and Building Technology. (2015), Planning Research on Development of Marine Bridge Foundation Large Circular Steel Pile Construction Method, Final Report 14RDPP-C090994-01, Korea Agency for Infrastructure Technology Advancement, 268p (in Korean).
5
Kim, J., Park, M.S., Jeong, Y.J., and Song, S. (2017), "Numerical Study on the Motion of a Large Marine Temporary Structure Using Submerged Cables under Construction", KSCE 2017 (Conference and Civil Expo), Korean Society of Civil Engineers, Busan, Korea, pp.275-276 (in Korean).
6
Lee, G.H. and Hong, G.Y. (2011), "A Study for the Evaluation of Ship Collision Forces for the Design of Bridge Pier", Journal of Korean Society of Civil Engineers, Vol.31, No.3A, pp.199-206 (in Korean).
7
Lee, J.H., Cho, J.W., and Kim, H.M. (2017), "Installation Method of Large Circular Steel Pipe Using Suction Pressure", KSCE 2017 (Conference and Civil Expo), Korean Society of Civil Engineers, Busan, Korea, pp.13-14 (in Korean).
8
Lee, M.J., Choi, S.K., Choo, H.W., Cho, Y.S., and Lee, W.J. (2008), "Uniformity of Large Gypsum-cemented Specimens Fabricated by Air Pluviation Method", Journal of the Korean Geotechnical Society, Vol.24, No.1, pp.91-99 (in Korean).
9
Lee, S.L. and Bae, Y.G. (2006a), "Ship Collision Risk Assessment for Bridges", Journal of Korean Society of Civil Engineers, Vol. 26, No.1A, pp.1-9 (in Korean).
10
Lee, S.L. and Bae, Y.G. (2006b), "Ship Collision Risk of Suspension Bridge and Design Vessel Load", Journal of Korean Society of Civil Engineers, Vol.26, No.1A, pp.11-19 (in Korean).
11
Saadeldin, R., Hu, Y., and Henni, A. (2015), "Numerical Analysis of Buried Pipes under Field Geo-environmental Conditions", International Journal of Geo-Engineering, Vol.6, No.6, pp.1-22.
10.1186/s40703-015-0005-4
12
Ssenyondon, V., Tran, V.A., and Kim, S.R. (2017), "Numerical Investigation on Seepage Stability in Offshore Bucket Cut-off Walls", Journal of the Korean Geotechnical Society, Vol.33, No.11, pp. 73-82 (in Korean).
13
Wang, L., Yang, L., Huang, D., Zhang, Z., and Chen, G. (2008), "An Impact Dynamics Analysis on a New Crashworthy Device Against Ship–bridge Collision", International Journal of Impact Engineering, Vol.35, No.8, pp.895-904.
10.1016/j.ijimpeng.2007.12.005
14
Yun, D.H., Suh, S.H., and Kim, Y.T. (2016), "Settlement and Scour Characteristics of Artificial Reef According to Reinforced Ground", Journal of Ocean Engineering and Technology, Vol.30, No.3, pp.186-193 (in Korean).
10.5574/KSOE.2016.30.3.186
15
Yun, H., Nayeri, R., Tasbihgoo, F., Wahbeh, M., Caffrey, J., Wolfe, R., Nigbor, R., Masri, S.F., Abdel-Ghaffar, A., and Sheng, L.H. (2008), "Monitoring the Collision of a Cargo Ship with the Vincent Thomas Bridge", Structural Control and Health Monitoring, Vol. 15, No.2, pp.183-206.
10.1002/stc.213
16
Zheng, Q., Han, B., and Ou, J. (2018), "Ship-bridge Collision Monitoring System based on Flexible Quantum Tunneling Composite with Cushioning Capability", Smart Materials and Structures, Vol.27, No.7, pp.1-9.
10.1088/1361-665X/aac362
Information
  • Publisher :The Korean Geotechnical Society
  • Publisher(Ko) :한국지반공학회
  • Journal Title :Journal of the Korean Geotechnical Society
  • Journal Title(Ko) :한국지반공학회 논문집
  • Volume : 34
  • No :11
  • Pages :81-92
  • Received Date : 2018-11-12
  • Revised Date : 2018-11-16
  • Accepted Date : 2018-11-19
  • DOI :https://doi.org/10.7843/kgs.2018.34.11.81
Journal Informaiton Journal of the Korean Geotechnical Society Journal of the Korean Geotechnical Society
Archives
: Vol.23~28 (2007~2012)
  • NRF
  • KOFST
  • KISTI Current Status
  • KISTI Cited-by
  • crosscheck
  • orcid
  • open access
  • ccl
Journal Informaiton Journal Informaiton - close